Hi Guys,
I finally managed to get a sound clip of the tapping my injectors make on my 2017 2.2
Latest PCM update and occurs whether engine hot or cold and same with hot or cold ambient temperature.
Used different injector cleaners, and brands of diesel.
PCM and injector learn, etc have been reset.
This happens under mid load, steady throttle acceleration from 2000rpm to about 2800rpm.
What are your thoughts?
Hopefully sound clip loads...
Information: Following the announcement on October 23, 2023, this site has been archived as of July 1, 2024. For further details, visit this page.
Injector Rattle/Tapping sound?
-
- Junior Member
- Posts: 5
- Joined: Fri Jul 02, 2021 10:24 pm
- Location: Brisbane
- Model Of Vehicle: RANGER XLT PX
- Year Of Vehicle: 2015
- Been thanked: 2 times
Try some Fuel Dr, worked for the same thing in my 3.2. I too tried a few different cleaners, additives, without much of a difference.
I know, I know, snake oil, sampling error, wishful thinking etc but in this case it did make a difference, was immediately a little quieter, but did get progressively better over a few succeeding tanks. Same thing, light load mild acceleration, about 2-2500 rpm. It's still there a tiny bit, but was much louder than yours to begin with, I kept checking the oil because I thought it was low, causing noisy hydraulic lifters.
I know, I know, snake oil, sampling error, wishful thinking etc but in this case it did make a difference, was immediately a little quieter, but did get progressively better over a few succeeding tanks. Same thing, light load mild acceleration, about 2-2500 rpm. It's still there a tiny bit, but was much louder than yours to begin with, I kept checking the oil because I thought it was low, causing noisy hydraulic lifters.
-
- Regular Member
- Posts: 143
- Joined: Fri Jan 25, 2019 7:48 pm
- Location: Pretoria
- Model Of Vehicle: RANGER XLS PX2
- Year Of Vehicle: 2017
- Forscan Dongle Type: OBDlink MX+ Black Bluetooth
- Has thanked: 40 times
- Been thanked: 10 times
Thanks for that.
Tried lubricity improvers, etc even (horrors) 2SO in the tank...
Is this the Fuel Dr you refer to:
https://fueldoctors.com.au/product/
If so, then i can get that here in South Africa:
https://fueldoctors.co.za/
I'll give it a go then.
Did you do the initial fill dosage of 500ml per 100l for each tank or only the first tank?
Have you continued to use Fuel Dr?
If you have stopped using it, did the injectors remain quieter?
My concern with all this is that the injectors are actually on their way out and will cause damage down the line regardless of whether I get them quieter. Unless it is just dirt that gets cleaned off with this treatment.
Tried lubricity improvers, etc even (horrors) 2SO in the tank...
Is this the Fuel Dr you refer to:
https://fueldoctors.com.au/product/
If so, then i can get that here in South Africa:
https://fueldoctors.co.za/
I'll give it a go then.
Did you do the initial fill dosage of 500ml per 100l for each tank or only the first tank?
Have you continued to use Fuel Dr?
If you have stopped using it, did the injectors remain quieter?
My concern with all this is that the injectors are actually on their way out and will cause damage down the line regardless of whether I get them quieter. Unless it is just dirt that gets cleaned off with this treatment.
-
- Junior Member
- Posts: 5
- Joined: Fri Jul 02, 2021 10:24 pm
- Location: Brisbane
- Model Of Vehicle: RANGER XLT PX
- Year Of Vehicle: 2015
- Been thanked: 2 times
Yes that's the right stuff. Yes I still use it, so I'm not sure if they would stay quiet or not if I stopped. I should give it a try. I live in the subtropics here so water in fuel is always a possibility so I've kept on using it.
-
- Regular Member
- Posts: 143
- Joined: Fri Jan 25, 2019 7:48 pm
- Location: Pretoria
- Model Of Vehicle: RANGER XLS PX2
- Year Of Vehicle: 2017
- Forscan Dongle Type: OBDlink MX+ Black Bluetooth
- Has thanked: 40 times
- Been thanked: 10 times
What dosage are you still using though? Still the 500ml per 100l ratio?