SSM 46644 - Ranger and Everest/Endeavour Vehicles Equipped with a Diesel Engine - Cold Start and Running Concerns - Glow Plug Failures
Some Ranger and Everest/Endeavour vehicles equipped with a diesel engine, may experience difficulty in starting and running in cold weather. This may be attributed to a failure of one or more glow plugs. If after following the correct diagnostic procedures it is found that one or more glow plugs are found to be the root cause, ALL glow plugs should be replaced. For additional information, refer to Workshop Manual (WSM) Section 303-07B/C. Please use the available service labor operation number(s) from section 6 of the Service Labor Time Standards (SLTS) manual and refer to this SSM when completing a claim. SSM: 46644
APPLICABLE VEHICLES
2015 TRUCK: EB U375 EVEREST APA
2015 - 2017 TRUCK: EC U375 EVEREST
2015 - 2017 TRUCK: EC U375 EVEREST
2015 TRUCK: EC U375 EVEREST
2015 - 2017 TRUCK: EC U375 EVEREST
2015 - 2017 TRUCK: EC U375 EVEREST
2015 TRUCK: EC U375 EVEREST
2015 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2017 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2012 - 2015 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2015 - 2017 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2012 - 2015 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2015 - 2017 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2011 - 2015 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2016 - 2017 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2015 - 2017 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2011 - 2015 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
2016 - 2017 TRUCK: KD GLOBAL COMPACT PICKUP-MAZ AAT
Information: Following the announcement on October 23, 2023, this site has been archived as of July 1, 2024. For further details, visit this page.
SSM 46644 -Glow Plug Failures - Effective Jun 7 2017
- saeb
- Site Admin
- Posts: 4169
- Joined: Wed May 17, 2017 8:50 pm
- Location: Seaford VIC
- Model Of Vehicle: RANGER XLT PX2
- Year Of Vehicle: 2015
- Forscan Dongle Type: Ford VCM
- Has thanked: 295 times
- Been thanked: 1063 times
Stewart
Ford PX2 Supercab 2015 Automatic
Ford PX2 Supercab 2015 Automatic
- Spook
- Donator
- Posts: 12
- Joined: Sat Jun 17, 2017 2:39 pm
- Location: MNC, NSW, Australia
- Model Of Vehicle: OTHER
- Year Of Vehicle: 2022
- Forscan Dongle Type: OBDlink MX+ Black Bluetooth
I had a P0675 DTC (cylinder 5 glow plug) which was repaired under warranty. Looks like they didnt read this though because in the job notes they say they only replaced the one plug.
Spook
Current:
2022 Metro Grey V6 XLT.
Previous:
2016 PX2 XLT Dual Cab - Auto, White - No Mods
2013 PX XL Dual Cab - Auto, Silver, ARB Winch Bar, TJM Rear, 2 Inch OME Lift
Current:
2022 Metro Grey V6 XLT.
Previous:
2016 PX2 XLT Dual Cab - Auto, White - No Mods
2013 PX XL Dual Cab - Auto, Silver, ARB Winch Bar, TJM Rear, 2 Inch OME Lift
- saeb
- Site Admin
- Posts: 4169
- Joined: Wed May 17, 2017 8:50 pm
- Location: Seaford VIC
- Model Of Vehicle: RANGER XLT PX2
- Year Of Vehicle: 2015
- Forscan Dongle Type: Ford VCM
- Has thanked: 295 times
- Been thanked: 1063 times
What was the date of replacement, after or before June 7th?
Stewart
Ford PX2 Supercab 2015 Automatic
Ford PX2 Supercab 2015 Automatic
-
- Junior Member
- Posts: 22
- Joined: Thu Jul 27, 2017 3:14 am
- Location: England
- Model Of Vehicle: RANGER LIMITED PX2 SA BUILT
- Year Of Vehicle: 2016
Mine had this issue, all plugs faulty from factory and needed replacing. Of course this was only discovered in the winter when it wouldn't start at a mere -5 degrees, was seriously annoying.
Astro
2016 Ranger Limited
Panther Black
2016 Ranger Limited
Panther Black
- saeb
- Site Admin
- Posts: 4169
- Joined: Wed May 17, 2017 8:50 pm
- Location: Seaford VIC
- Model Of Vehicle: RANGER XLT PX2
- Year Of Vehicle: 2015
- Forscan Dongle Type: Ford VCM
- Has thanked: 295 times
- Been thanked: 1063 times
Appears to be a common occurrence.
First sign is blue smoke on startup even after waiting for glow plug light to extinguish.
If I wait for the light to extinguish then no smoke and start with out waiting then smoke.
First sign is blue smoke on startup even after waiting for glow plug light to extinguish.
If I wait for the light to extinguish then no smoke and start with out waiting then smoke.
Stewart
Ford PX2 Supercab 2015 Automatic
Ford PX2 Supercab 2015 Automatic
- Spook
- Donator
- Posts: 12
- Joined: Sat Jun 17, 2017 2:39 pm
- Location: MNC, NSW, Australia
- Model Of Vehicle: OTHER
- Year Of Vehicle: 2022
- Forscan Dongle Type: OBDlink MX+ Black Bluetooth
Mine was only done last week and the only symptom (apart from the kids complaining of the exhaust stink in the morning) was the DTC.
Spook
Current:
2022 Metro Grey V6 XLT.
Previous:
2016 PX2 XLT Dual Cab - Auto, White - No Mods
2013 PX XL Dual Cab - Auto, Silver, ARB Winch Bar, TJM Rear, 2 Inch OME Lift
Current:
2022 Metro Grey V6 XLT.
Previous:
2016 PX2 XLT Dual Cab - Auto, White - No Mods
2013 PX XL Dual Cab - Auto, Silver, ARB Winch Bar, TJM Rear, 2 Inch OME Lift
-
- New Member
- Posts: 2
- Joined: Sun Aug 27, 2017 7:59 pm
- Location: Australia
- Model Of Vehicle: EVEREST TREND UA
- Year Of Vehicle: 2015
So Interestingly I found that I had P0673 DTC (cylinder 3 glow plug) which freeze framed at 35000km based on the engine sounding a off during the winter months when cold. This was spotted by a friend who has an OBD2 scanner @39000km
After booking it in at my local dealer I picked it up with the following on the work card. "No Codes found, PCM firmware updated, engine operating normally"
This puzzled me so I purchased an ODB2 and after plugging it in at 41900km low and behold I have P0673 DTC (cylinder 3 glow plug) which freeze framed at 40103km.
Why did the dealer not see the code why did they not apply the service bulletin.... FML
After booking it in at my local dealer I picked it up with the following on the work card. "No Codes found, PCM firmware updated, engine operating normally"
This puzzled me so I purchased an ODB2 and after plugging it in at 41900km low and behold I have P0673 DTC (cylinder 3 glow plug) which freeze framed at 40103km.
Why did the dealer not see the code why did they not apply the service bulletin.... FML
Everest Trend 2015 Cool White Tugboat!
- saeb
- Site Admin
- Posts: 4169
- Joined: Wed May 17, 2017 8:50 pm
- Location: Seaford VIC
- Model Of Vehicle: RANGER XLT PX2
- Year Of Vehicle: 2015
- Forscan Dongle Type: Ford VCM
- Has thanked: 295 times
- Been thanked: 1063 times
Take it back and spell it out in black and white. Have them do the correct TSB or lodge a complaint with head office. Also remember the TSB is June 2017 onward and not every dealer reads them unless its pointed out.
Stewart
Ford PX2 Supercab 2015 Automatic
Ford PX2 Supercab 2015 Automatic
- Spook
- Donator
- Posts: 12
- Joined: Sat Jun 17, 2017 2:39 pm
- Location: MNC, NSW, Australia
- Model Of Vehicle: OTHER
- Year Of Vehicle: 2022
- Forscan Dongle Type: OBDlink MX+ Black Bluetooth
I agree with saeb you have to be very specific with the service department. My conversation when I dropped it off went something like:
"My ranger has a fault code showing P0675 which is a glow plug fault"
"So you want us to reset the fault code?"
"No I want you to fix what is causing the fault code!?"
"My ranger has a fault code showing P0675 which is a glow plug fault"
"So you want us to reset the fault code?"
"No I want you to fix what is causing the fault code!?"
Spook
Current:
2022 Metro Grey V6 XLT.
Previous:
2016 PX2 XLT Dual Cab - Auto, White - No Mods
2013 PX XL Dual Cab - Auto, Silver, ARB Winch Bar, TJM Rear, 2 Inch OME Lift
Current:
2022 Metro Grey V6 XLT.
Previous:
2016 PX2 XLT Dual Cab - Auto, White - No Mods
2013 PX XL Dual Cab - Auto, Silver, ARB Winch Bar, TJM Rear, 2 Inch OME Lift
-
- Junior Member
- Posts: 40
- Joined: Sun Jul 02, 2017 7:39 pm
- Location: Philippines
- Model Of Vehicle: RANGER LIMITED PX2 SA BUILT
- Year Of Vehicle: 2016
- Has thanked: 19 times
- Been thanked: 3 times
Hi Stewart!
Do we have news on latest set of TSB's?
A friend of mine just got a letter from Ford for a late 2017 Everest needing a PCM update to fix glow plug issues.
Thanks!
Do we have news on latest set of TSB's?
A friend of mine just got a letter from Ford for a late 2017 Everest needing a PCM update to fix glow plug issues.
Thanks!
Everest Trend 2.2L PH model
- saeb
- Site Admin
- Posts: 4169
- Joined: Wed May 17, 2017 8:50 pm
- Location: Seaford VIC
- Model Of Vehicle: RANGER XLT PX2
- Year Of Vehicle: 2015
- Forscan Dongle Type: Ford VCM
- Has thanked: 295 times
- Been thanked: 1063 times
No mate, I have not bought a subscription for a while. I'm unsure when I will be paying the next one as yet.
Stewart
Ford PX2 Supercab 2015 Automatic
Ford PX2 Supercab 2015 Automatic