Information: Following the announcement on October 23, 2023, this site has been archived as of July 1, 2024. For further details, visit this page.
Finally fitted the turbo
-
- Donator
- Posts: 199
- Joined: Fri May 26, 2017 9:52 pm
- Has thanked: 53 times
- Been thanked: 38 times
finally fitted the new garret turbo. Easy job. Few bolts here and there. Worthwhile upgrade. Billet compressor wheel and shaft. Better bearings. Garret claim 20% increase in flow without a tune. This thing whistles like a kettle now! Spools up significantly quicker and gets up and goes. Above all more reliable when out remote.
Last edited by Lincolnland on Mon Sep 05, 2022 1:08 pm, edited 1 time in total.
-
- Donator
- Posts: 8
- Joined: Fri Apr 29, 2022 9:33 am
- Location: Tasmania
- Model Of Vehicle: RANGER XLT PX
- Year Of Vehicle: 2012
Nice. I'm sure that it wouldnt take much to design a better unit but 20% increase without a tune is a bit bold though... the MAP sensor might be getting in the way of that.
Ranger XLT 2012
-
- Donator
- Posts: 199
- Joined: Fri May 26, 2017 9:52 pm
- Has thanked: 53 times
- Been thanked: 38 times
Yeah the Garret Turbo Charger GTB2256VK. Good bit of gear. Based on the gtx gen2. Specs available everywhere and a cheap upgrade at $1700. Reason for upgrade was the reliability not the power...It is a bonus though
-
- Donator
- Posts: 50
- Joined: Mon Oct 15, 2018 8:39 am
- Location: Bairnsdale
- Model Of Vehicle: RANGER XLT PX2
- Year Of Vehicle: 2018
- Forscan Dongle Type: SAEB Forscan Dongle WIN7
- Been thanked: 4 times
Curious on your concern for reliability, I assume a 3.2? I change the oil every 10k and allow the oil to warm up a bit before putting my foot into it and also let it idle down a bit too.
110k tuned and still going strong. I was going to replace turbo but funds where tight so will see how many more kms.
Good to know the alternative works well
110k tuned and still going strong. I was going to replace turbo but funds where tight so will see how many more kms.
Good to know the alternative works well
Glenn
-
- Regular Member
- Posts: 143
- Joined: Fri Jan 25, 2019 7:48 pm
- Location: Pretoria
- Model Of Vehicle: RANGER XLS PX2
- Year Of Vehicle: 2017
- Forscan Dongle Type: OBDlink MX+ Black Bluetooth
- Has thanked: 40 times
- Been thanked: 10 times
I stand under correction but as far as i know it was the PX1 3.2 turbo's that were a bit less reliable. PX2 allegedly a better unit.GE350 wrote: ↑Fri Dec 02, 2022 9:29 am Curious on your concern for reliability, I assume a 3.2? I change the oil every 10k and allow the oil to warm up a bit before putting my foot into it and also let it idle down a bit too.
110k tuned and still going strong. I was going to replace turbo but funds where tight so will see how many more kms.
Good to know the alternative works well
Perhaps he has a PX1?
-
- Donator
- Posts: 159
- Joined: Mon Apr 22, 2019 12:02 am
- Location: Canberra
- Model Of Vehicle: RANGER XLT PX3
- Year Of Vehicle: 2019
- Forscan Dongle Type: OBDlink MX Black Bluetooth
- Has thanked: 14 times
- Been thanked: 39 times
Yes, 3.2.
The PX2/3 uses a turbo with a smaller shaft that can be prone to failure (even without additional boost). Australia is a big place when you're somewhere remote.
The Powermax unit appears to be a noticebly stronger unit and can move about 10-15% more air at a similar boost level.
Ian B
PX3 XLT 3.2
PX3 XLT 3.2
-
- Donator
- Posts: 199
- Joined: Fri May 26, 2017 9:52 pm
- Has thanked: 53 times
- Been thanked: 38 times
The GCG website has a wealth of information on upgraded turdbos for all flavours of px ranger. As mentioned above the turbo upgrade is a reliability upgrade. As is the intercooler and silicone hoses. Attempting to have a trouble free, reliable powerplant for the remote touring especially when towing.